2023 Explorer ST Exhaust stutters on Startup

[Xalm]

Hello, My ST exhaust pops and stutters a bit on startup, doesn't seem to affect performance at all, and can rev it a bit and seems to clear up quickly. But it is not smooth sounding at all. I have a FP Tune on it and a 3" Thermal R&D. Any ideas on the cause? thought about slapping the stock exhaust on it to see if it goes away, but wanted some opinions before i tackled that process.

 

[Peteroo]

mine has a bit of a "miss" or stumble while idleing fwiw. stock 23

 

[Blue Beast]

Hello, My ST exhaust pops and stutters a bit on startup, doesn't seem to affect performance at all, and can rev it a bit and seems to clear up quickly. But it is not smooth sounding at all. I have a FP Tune on it and a 3" Thermal R&D. Any ideas on the cause? thought about slapping the stock exhaust on it to see if it goes away, but wanted some opinions before i tackled that process.

Welcome to the forum.

 

[Tracked]

Mine does the same as well, though only noticed it when I put my Thermal on. I assume it's always done that and the stock exhaust hides it. Goes away in less than a minute.

 

[KNTRDR]

Stock 2020, has been doing it all along. Only seems to do it on a cold start. Goes away in a short time.

I run 87 octane, not sure if it’s possibly adjusting ignition timing to compensate for the lower octane. 120,000km and no problems so far.

 

[willh876]

I have a thermal 3 inch as well. I've noticed it on all my starts. It's Will sound quite and then pop and goes away. Sometimes it sounds louder on one side. Once it warms up after like 30 seconds and quotes down I don't notice it.

 

[Cajun Heat]

Hello, My ST exhaust pops and stutters a bit on startup, doesn't seem to affect performance at all, and can rev it a bit and seems to clear up quickly. But it is not smooth sounding at all. I have a FP Tune on it and a 3" Thermal R&D. Any ideas on the cause? thought about slapping the stock exhaust on it to see if it goes away, but wanted some opinions before i tackled that process.

That is normal for a cold start as long as it goes away once it idles down.